- It is difficult to start a cold vehicle, with large vibration after starting, and large vibration at medium and low speeds. It may be a spark plug failure or premature ignition. It is recommended to go to the nearest service station for maintenance in time.
- Difficulty to start at low temperature in winter. Mainly: the temperature is low, the vaporization rate of the fuel drops; the mixer becomes thinner and is not easy to burn, which causes difficulty in starting; the viscosity of the lubricating oil increases, and the resistance of the engine increases, which causes difficulty in starting; the chemical reaction of the battery electrolyte is slow, causing the start Insufficient power output, insufficient starter power and insufficient ignition voltage make it difficult for the engine to start.
Before starting the garbage truck in the cold season, the engine should be warmed up to avoid difficulty in starting at low temperatures in winter.
- Garbage truck engine lubrication
- The lubricating oil pressure indicator will light up when accelerating. Indicates that the oil pressure is too low. It may be caused by clogged filter, low lubricating oil, and oil pump failure. It is recommended to go to the nearest service station for maintenance in time. Or the lubricating oil pressure indicator system is malfunctioning and the indicator light is turned on by mistake. It is recommended to go to the nearest service station for maintenance in time.
- Excessive lubricating oil consumption. Lubricating oil is normally consumed when the car is in good condition, but when the car is in poor condition, the exhaust of the car turns blue, which means that the lubricating oil is consumed too much. The main reason for the consumption of lubricating oil is entering the combustion chamber to participate in the combustion Or lubricant leakage. It is recommended to check and repair the nearest service station in time.
- Unstable operation of garbage truck generator
- The throttle body of the engine is dirty or the motor is malfunctioning. When the throttle valve and idle speed valve of the engine valve body are seriously dirty, the engine will experience low idle speed, poor stability or no idle speed, and the throttle valve will be stuck when refueling. Generally, it is recommended to clean the throttle body when the vehicle travels about 20,000 kilometers. After cleaning, it should be set by the diagnostic instrument to achieve a normal working attitude.
- The engine shakes severely, and the fault indicator will flash occasionally. The reason is that unclean fuel has caused pollution or blockage of the fuel supply system. The use of dirty fuel will cause pollution of the fuel supply, ignition, and exhaust systems, which will lead to the lighting of the engine failure indicator and varying degrees of engine jitter.
The solution is to thoroughly clean the contaminated system, continue to add gasoline with stable indicators and add a certain amount of oil line cleaner.
- The exhaust color of the garbage truck engine.
- The exhaust color of garbage truck is blue. In the garbage truck, a large amount of lubricating oil enters the cylinder and cannot complete the combustion; sometimes the engine starts to emit blue smoke when cold, but it will be fine when the truck is hot. It is recommended to go to a dedicated vehicle repair point for maintenance in time.
- The exhaust color of garbage truck is black. Due to incomplete fuel combustion. It will cause a decline in power and economic deterioration. It is recommended to go to a dedicated vehicle repair point for maintenance in time.
- The color of the garbage truck is white, and it is serious when the car is cold, and the white smoke will not be emitted when the car is hot. This is because gasoline contains water and the engine is too cold. At this time, the fuel entering the cylinder is not completely burned, causing fog or water vapor to form white smoke. When the car is started for the first time in winter or rainy season, white smoke can often be seen. Once the engine temperature rises, the white smoke will rise. This state does not need to be overhauled.